Solar/wind energy
- Thread starter rosemari
- Start date
The friendliest place on the web for anyone who enjoys boating.
If you have answers, please help by responding to the unanswered posts.
If you have answers, please help by responding to the unanswered posts.
That is a pretty open ended question, so here are some more to narrow it down:
What kind of boat and where do you plan to put the panels.
How do you use the boat and what are you trying to accomplish with panels
How much battery capacity and how much amperage do you draw in an average day
David
What kind of boat and where do you plan to put the panels.
How do you use the boat and what are you trying to accomplish with panels
How much battery capacity and how much amperage do you draw in an average day
David
Don't have the boat yet, it will be a wooden trawler. I just assumed that the panels would have to go on the roof or there abouts. We live in Canada and so far we plan on just exploring the west coast at first. We would like to have the solar/wind power sustain us and have generator as a back up.
kthoennes
Guru
- Joined
- Oct 11, 2013
- Messages
- 2,526
- Location
- USA
- Vessel Name
- Xanadu
- Vessel Make
- Mainship 37 Motor Yacht
I know what you mean about an overwhelming amount of info on the net - and boating forums. We're not adding solar on the boat yet, just not worth it (yet) with a quiet, well running generator on board but I did just buy a semi-flexible 40 watt panel and battery to power small dock lights (like landing lights at the airport) and to light the boat name inset into the dock. The panel is about 20" x 24" and cost around $65, mounted on the lid of our dock box, and tough enough to sit on. I am amazed at what that thing puts out, even on a gray or cloudy day. They've come a long way. The technology is getting really impressive.
BruceK
Moderator Emeritus
- Joined
- Oct 31, 2011
- Messages
- 13,549
- Vessel Name
- Sojourn
- Vessel Make
- Integrity 386
First response is yes, do it. Specific advice is often specific to a particular boat, but maybe you want a boat which will accommodate solar/wind. I know little about wind power but almost any boat should take a generator. With solar, you want your panels as unshadowed as possible, even a rigging line casting a shadow affects output, and an inch of cooling airspace underneath.
There are good internet articles, you have to separate wheat from chaff. Read up, then ask. Several boats here have significant solar set ups, they may post and help. Mine is just 180w, but the batts are always full, and they run a 12v fridge during daytime with the batts holding well. Plus I have a 25w panel dedicated to the genset batt. Well charged batts last much much longer.You need good controllers, MPPT are state of the art, mine are older but good, most give info on amps/watts in current day and days before.
There are good internet articles, you have to separate wheat from chaff. Read up, then ask. Several boats here have significant solar set ups, they may post and help. Mine is just 180w, but the batts are always full, and they run a 12v fridge during daytime with the batts holding well. Plus I have a 25w panel dedicated to the genset batt. Well charged batts last much much longer.You need good controllers, MPPT are state of the art, mine are older but good, most give info on amps/watts in current day and days before.
Cat Daddy
Senior Member
Another benefit of a MPPT controller is higher input voltage allowing the use of residential style solar panels that can be found for under $1 per watt. Also less voltage drop allowing smaller wire.
For my installation I used 2 - 240 watt panels in series feeding 70 volts dc to the MPPT controller. Seems to be working well.
Rafe
For my installation I used 2 - 240 watt panels in series feeding 70 volts dc to the MPPT controller. Seems to be working well.
Rafe
AusCan
Guru
- Joined
- Jul 15, 2012
- Messages
- 3,219
- Location
- Australia
- Vessel Name
- Kokanee
- Vessel Make
- Cuddles 30 Pilot House Motor Sailer
The first step is working out how much power you will need away from the dock.
Do you just want to run a few LED lights and a small fridge for a day or two while at anchor? Easily do-able with solar.
Or do you want to run a house sized fridge & freezer, microwave, TV, computer etc for weeks away from the dock? Can be done with solar, with enough roof space, battery space, and money.
A/C, electric stove, watermaker, ice maker…. Buy a generator.
Do you just want to run a few LED lights and a small fridge for a day or two while at anchor? Easily do-able with solar.
Or do you want to run a house sized fridge & freezer, microwave, TV, computer etc for weeks away from the dock? Can be done with solar, with enough roof space, battery space, and money.
A/C, electric stove, watermaker, ice maker…. Buy a generator.
Martin J
Guru
I have done this too my last 2 boats the first was my C&L Sea Ranger 60 4x200+wat panels, Blue Sky controller, 14x L16 batteries Approx 2800amps. The payback from not running a generator or using shore power was under 2 years. I calculated this from a cumulative watt meter. Best investment ever made! Plus no noisy genny at anchor etc.
My current boat Cheoy Lee 50 Tri-cabin I did over 2 years ago with 4x235watt panels and a Maverick controller, and 10 XT105Plus batteries (1125 Amps) I would have liked more batteries however no room. It saved $400 a month of my marina elec per month plus the lack of having to run the genny while away. Payback was less than 6 months. I did this work in Sint Maarten where things are much cheaper (Panels are 1$ per watt)
My current boat Cheoy Lee 50 Tri-cabin I did over 2 years ago with 4x235watt panels and a Maverick controller, and 10 XT105Plus batteries (1125 Amps) I would have liked more batteries however no room. It saved $400 a month of my marina elec per month plus the lack of having to run the genny while away. Payback was less than 6 months. I did this work in Sint Maarten where things are much cheaper (Panels are 1$ per watt)
Diesel Duck
Senior Member
FWIW, below is a copy and paste from the DuckTalk.net forum of what a Diesel Duck owner said about his solar and wind generator equipped brand new Diesel Duck 462:
The power went out for four+ days on the docks here at the Subic Bay Yacht club in the Philippines. As I walked the docks after a couple of days you could hear beeps coming from unattended boat after boat. One by one the beeps slowly died as their batteries probably died. It was so great that for the four days I did not have to start the generator once. The solar panels and wind generator kept my refrigerator cold, powered my all LED lights, ran my cabin fans, ran my fresh water system and toilets, I was able to cook and it powered my inverter for TV/DVD use. It was also nice to know that if I had left my boat unattended I would have returned to full batteries. Completely discharging your batteries damages them and leads to reduced life span. An 800 amp hour 24V AGM battery bank is $1000s to replace. I can't recommend these type of systems enough. There is basically no maintenance, were inexpensive to install and work phenomenal. It also helped that the systems I mentioned above are all very efficient 24v systems except my stove/oven which is a really neat 3 burner gas, one burner electric model. I specifically equipped my Duck to be 100% powered by renewable energy (if need be) with it's ketch sailing rig, feathering prop, solar panels and wind generator, efficient 24v systems and large AGM battery bank. I am very happy to say I accomplished that.
The power went out for four+ days on the docks here at the Subic Bay Yacht club in the Philippines. As I walked the docks after a couple of days you could hear beeps coming from unattended boat after boat. One by one the beeps slowly died as their batteries probably died. It was so great that for the four days I did not have to start the generator once. The solar panels and wind generator kept my refrigerator cold, powered my all LED lights, ran my cabin fans, ran my fresh water system and toilets, I was able to cook and it powered my inverter for TV/DVD use. It was also nice to know that if I had left my boat unattended I would have returned to full batteries. Completely discharging your batteries damages them and leads to reduced life span. An 800 amp hour 24V AGM battery bank is $1000s to replace. I can't recommend these type of systems enough. There is basically no maintenance, were inexpensive to install and work phenomenal. It also helped that the systems I mentioned above are all very efficient 24v systems except my stove/oven which is a really neat 3 burner gas, one burner electric model. I specifically equipped my Duck to be 100% powered by renewable energy (if need be) with it's ketch sailing rig, feathering prop, solar panels and wind generator, efficient 24v systems and large AGM battery bank. I am very happy to say I accomplished that.
Last edited:
angus99
Guru
Has anyone used the federal (and/or state) renewable energy credit successfully? I'm told the fed credit applies to boats that qualify as second homes and the savings is off the top of any tax liability.
TDunn
Guru
- Joined
- Feb 23, 2015
- Messages
- 889
- Location
- USA
- Vessel Name
- Tortuga
- Vessel Make
- Nunes Brothers Raised Deck Cruiser
It is pretty straight forward to set up a solar array. I have a wooden boat so I wanted something to keep the batteries up for running the bilge pumps. I have a very simple electrical system (all LED lights, small refrigerator that draws 3.5 amps when running, webasto diesel heater that draws 3.2 amps on full) plus the bilge pumps. I have two 50 watt panels in parallel. Their peak output has been 8.6 amps. They are wired to a dual output controller than allows me to split the output between my house and start batteries in 10% increments. My batteries are always fully charged when I come on board. Today we were totally fogged in. My panels were putting our 3 amps despite the fog (I had the refer on). My panels are mounted on the cabin top where they get zero shade. I am very pleased with the solar system. I do not have shore power and have never had to charge the batteries except at the beginning of the season (the boat is stored inside where the solar panels don't work during the off season.
JDCAVE
Guru
- Joined
- Apr 3, 2011
- Messages
- 3,010
- Location
- Canada
- Vessel Name
- Phoenix Hunter
- Vessel Make
- Kadey Krogen 42 (1985)
I know one V/O who installed both solar and wind on his boat in the PNW. He's very pleased with the solar but wind generator was pretty much useless. I'd like to out ~500 watts of panels on our boat but that project might have to wait for another year.
Jim
Sent from my iPad using Trawler Forum
Jim
Sent from my iPad using Trawler Forum
twistedtree
Guru
I put 750 watts of solar on our boat when we built it. I would do the same again, but it's important to have realistic expectations.
Speaking generally.....
- Space will limit how much solar you can install.
- given the limit on how much solar you can install, it's worth doing everything possible to get the most out of it. This means maximizing the number of watts you can get from the available space. Pick panels that maximize this. Despite their appeal, this likely means not using flexible panels because of their low output per sq foot.
- once you have the most raw power available, get the most from it. This means using an MPPT charge controller. Also, make sure your panels are not shaded (as in ZERO shade) during primary daylight hours.
- even with all this, it is unlikely solar will power the boat for days on end at anchor. All you should expect is a reduction in generator run time/frequency. We find that our solar pretty much covers the boats power loads during the day when it's sunny, but it's not enough to do any recharging of the overnight draw on the batteries.
Speaking generally.....
- Space will limit how much solar you can install.
- given the limit on how much solar you can install, it's worth doing everything possible to get the most out of it. This means maximizing the number of watts you can get from the available space. Pick panels that maximize this. Despite their appeal, this likely means not using flexible panels because of their low output per sq foot.
- once you have the most raw power available, get the most from it. This means using an MPPT charge controller. Also, make sure your panels are not shaded (as in ZERO shade) during primary daylight hours.
- even with all this, it is unlikely solar will power the boat for days on end at anchor. All you should expect is a reduction in generator run time/frequency. We find that our solar pretty much covers the boats power loads during the day when it's sunny, but it's not enough to do any recharging of the overnight draw on the batteries.
maxhopper502
Veteran Member
The semi flexible lightweight panels that I have are supposedly the most efficient on the market at 20 plus percent, they are only less than a year old but so far no complaints.
twistedtree
Guru
Interesting. You wouldn't have a pointer to a make/model or a spec sheet, would you? The world is always moving so what was might no longer be what is.
maxhopper502
Veteran Member
http://www.alibaba.com/product-deta...1532901256.html?spm=a2700.7724838.35.1.VuLfAA
Times are a changing and these are probably already so last year. American made sunpower cells put together in China ( surprise surprise). I have got 15 of the 180 watt 24v panels and all working fine.
Times are a changing and these are probably already so last year. American made sunpower cells put together in China ( surprise surprise). I have got 15 of the 180 watt 24v panels and all working fine.
I am planning on installing residential panels as well, but the mounting brackets all stand off the surface an inch or more to accommodate the connectors underneath. I would much prefer a flush installation that is fully caulked and sealed.
Are marine panels different, do they install flush? Any suggestions otherwise?
RickB
Scraping Paint
- Joined
- Oct 20, 2007
- Messages
- 3,804
- Vessel Make
- CHB 48 Zodiac YL 4.2
Consider panel cooling. A hot panel produces less power.
Bay Pelican
Moderator Emeritus
Instructions for my panels, Kyocera, state to mount them at least one inch off of the deck so that the heat dissipates.
FF
Guru
- Joined
- Oct 12, 2007
- Messages
- 22,552
Living with Alt energy does NOT start with power generation ,or storage it starts with reducing the requirements for power.
Look up Home Power mag , for ideas.
It is usually 300%++ cheaper to reduce the power needs than create ,store, perhaps convert (inverter) then consume power.
It is painful to purchase a $1500 Sun Frost fridge or a $1100 RV propane fridge , rather than a $100 unit from the big box store , but it IS worth it.
Refrigeration is the biggest power hog and expensive to do to go a number of days without a noisemaker.
*******
"Are marine panels different, do they install flush? Any suggestions otherwise? "
The solar output drops off at higher temperatures , so a couple of inches of cooling space under the panel will have a better output.
Look up Home Power mag , for ideas.
It is usually 300%++ cheaper to reduce the power needs than create ,store, perhaps convert (inverter) then consume power.
It is painful to purchase a $1500 Sun Frost fridge or a $1100 RV propane fridge , rather than a $100 unit from the big box store , but it IS worth it.
Refrigeration is the biggest power hog and expensive to do to go a number of days without a noisemaker.
*******
"Are marine panels different, do they install flush? Any suggestions otherwise? "
The solar output drops off at higher temperatures , so a couple of inches of cooling space under the panel will have a better output.
Last edited:
12cf SunFrost is $2500 and uses 0.5 kwhr daily.
12cf Samsung (digital inverter technology) is $825. Predicted energy use is difficult to get numbers for.
The difference in price of $1700 will buy enough solar panels, controller and small inverter to run the household fridge. Plus there are the benefits of having some 110v/220v for other uses and green energy production.
A tough decision either way, because it's not always about dollars, but also about one's values, philosophy and dedication to the environment.
CPseudonym
Moderator Emeritus
Great. How will your boat look with an extra 1700 watts of panels mounted on it solely dedicated to the fridge?
twistedtree
Guru
You're absolutely correct. Those are slightly higher power per sq meter than the rigid panels that I have.
FF
Guru
- Joined
- Oct 12, 2007
- Messages
- 22,552
12cf Samsung (digital inverter technology) is $825. Predicted energy use is difficult to get numbers for.
A rough estimate can be made by reading the yellow tag in any refrigerator.
It has annual power consumption , divide bt 356 and you will have a very rough guesstimate.
The sticker is always WRONG as it is not required to count the heating elements in the door seal or the insulation.in with the insulation.
Thin insulation must be heated frequently to drive out the water , which is a poor insulator.
Amazing what disinformation K street can purchase from congress.
Dometic Servel RGE400 non-electric propane refrigerator ...
https://www.thenaturalhome.com/servel400.php
Known for their reliability, we constantly hear of Servel LP gas refrigerators still purring along several decades later. Continuously produced by Electrolux® of ...
Vintage Servel Refrigerators Homepage
vintageservelrefrigerators.8k.com/
For those who love and admire old SERVEL refrigerators!
Servel LP, propane, kerosene refrigerators by Dometic
www.[B]servelrefrigerators[/B].com/
Dometic - dependable propane gas refrigerators don't need electricity.
WE prefer propane as no electric is required , so no noise for a year is easy to do.
The Servelle units made for the Amish are for homes so do not skimp on the insulation as the RV units must.
A rough estimate can be made by reading the yellow tag in any refrigerator.
It has annual power consumption , divide bt 356 and you will have a very rough guesstimate.
The sticker is always WRONG as it is not required to count the heating elements in the door seal or the insulation.in with the insulation.
Thin insulation must be heated frequently to drive out the water , which is a poor insulator.
Amazing what disinformation K street can purchase from congress.
Dometic Servel RGE400 non-electric propane refrigerator ...
https://www.thenaturalhome.com/servel400.php
Known for their reliability, we constantly hear of Servel LP gas refrigerators still purring along several decades later. Continuously produced by Electrolux® of ...
Vintage Servel Refrigerators Homepage
vintageservelrefrigerators.8k.com/
For those who love and admire old SERVEL refrigerators!
Servel LP, propane, kerosene refrigerators by Dometic
www.[B]servelrefrigerators[/B].com/
Dometic - dependable propane gas refrigerators don't need electricity.
WE prefer propane as no electric is required , so no noise for a year is easy to do.
The Servelle units made for the Amish are for homes so do not skimp on the insulation as the RV units must.
Similar threads
